Omega Owners Forum
Chat Area => General Car Chat => Topic started by: Doctor Gollum on 11 July 2023, 22:44:30
-
Just dug the battery out of the boot.
Showing less than 5v. Genuine Merc/Varta AGM battery, apparently made in December '22 :o
I presume 7 months isn't a normal battery life expectancy.
I also presume that there's no point trying to charge it with a regular Helfrods battery charger...
-
Yeh give it a go! What can possibly go wrong? :)
-
Always go for a charge, nothing to lose, that said lead acid sulphates fast when discharged.
Might be a quiescent drain somewhere
-
I'd use a smart battery charger, not a traditional type, and set it to the reconditioning / repair setting which goes through a staged reconditioning cycle, rather than just blasting charge into it regardless. Depending on the reason for the low voltage, or how long it has been left in that condition, you may (possibly) recover it, but standing with a low state of charge doesn't do a battery any good.
But you must know this.. ::)
Depending obviously on where you sourced the car from, is there no redress from them?
-
I'd use a smart battery charger, not a traditional type, and set it to the reconditioning / repair setting which goes through a staged reconditioning cycle, rather than just blasting charge into it regardless. Depending on the reason for the low voltage, or how long it has been left in that condition, you may (possibly) recover it, but standing with a low state of charge doesn't do a battery any good.
But you must know this.. ::)
Depending obviously on where you sourced the car from, is there no redress from them?
5 volts might be a bit too low for a smart charger to start charging, smart chargers generally need to 'see' a bit more voltage first.
-
Always go for a charge, nothing to lose, that said lead acid sulphates fast when discharged.
Might be a quiescent drain somewhere
One thing at a time ;) Car has barely done a whole 2,000 miles since January.
-
I'd use a smart battery charger, not a traditional type, and set it to the reconditioning / repair setting which goes through a staged reconditioning cycle, rather than just blasting charge into it regardless. Depending on the reason for the low voltage, or how long it has been left in that condition, you may (possibly) recover it, but standing with a low state of charge doesn't do a battery any good.
But you must know this.. ::)
Depending obviously on where you sourced the car from, is there no redress from them?
I asked the question as it's the first AGM battery I have come across. Technically,it shouldn't have one fitted as it isn't a stop/start equipped car. And if I need to buy a smart charger to charge the incorrect battery in the car, I may as well buy the correct size/capacity battery. ::)
Car was purchased in the knowledge that it might need a consumer battery, the surprise was what was fitted.
I know full well what sitting does to batteries having been through that with my Omegas and the newer Mercs have a reputation for higher current draws than might be expected, especially if left sat
-
IME, AGM batteries when well looked after do not last as long as non AGM, but you still expect 5+ years from them (if looked after)
As you know, any battery allowed to be deep discharged, or kept for long periods in semi discharged state will suffer permement damage that reduces their capacity.
Its rare to see these magical conditioners fix these issues, but if you already have a good charger with the function, and the batt is shagged anyway.... ;)
-
IME, AGM batteries when well looked after do not last as long as non AGM, but you still expect 5+ years from them (if looked after)
As you know, any battery allowed to be deep discharged, or kept for long periods in semi discharged state will suffer permement damage that reduces their capacity.
Its rare to see these magical conditioners fix these issues, but if you already have a good charger with the function, and the batt is shagged anyway.... ;)
I don't and I presume it is ;)
Will start with the correct battery and work through any gremlins from there ;)
-
I'd use a smart battery charger, not a traditional type, and set it to the reconditioning / repair setting which goes through a staged reconditioning cycle, rather than just blasting charge into it regardless. Depending on the reason for the low voltage, or how long it has been left in that condition, you may (possibly) recover it, but standing with a low state of charge doesn't do a battery any good.
But you must know this.. ::)
Depending obviously on where you sourced the car from, is there no redress from them?
5 volts might be a bit too low for a smart charger to start charging, smart chargers generally need to 'see' a bit more voltage first.
That's true of smart chargers in a normal charge mode, but the recon / repair mode enables them to 'attempt' to go through the repair cycle on a very low voltage or a flat battery, unless of course it is totally goosed. Although in my experience once you have to start using this mode it is knackered anyway and needs replacing.
-
Alternator is showing 14.56v across the front battery and 14.48 across the rear, so can only conclude that the battery is done.
-
Alternator is showing 14.56v across the front battery and 14.48 across the rear, so can only conclude that the battery is done.
Do you have facility to full charge the batt off the car? Before you do the honourable thing and condem it completely.
-
Alternator is showing 14.56v across the front battery and 14.48 across the rear, so can only conclude that the battery is done.
Do you have facility to full charge the batt off the car? Before you do the honourable thing and condem it completely.
I do now ;)
The Bosch S3013 currently fitted seems to have done the job ;)
-
Currently boiling away...
-
Turned it off for the night, but has got it up to 11.4V.
See what it says in the morning :-\
-
Currently boiling away...
That's never good for an AGM. ;)
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
-
I'd use a smart battery charger, not a traditional type, and set it to the reconditioning / repair setting which goes through a staged reconditioning cycle, rather than just blasting charge into it regardless. Depending on the reason for the low voltage, or how long it has been left in that condition, you may (possibly) recover it, but standing with a low state of charge doesn't do a battery any good.
But you must know this.. ::)
Depending obviously on where you sourced the car from, is there no redress from them?
They don't work, must have tried it 30+ times in the last 7 years with a Ctek and homebrew device on many different batteries and it never made a jot of difference. Which is actually not that surprising, as all its doing is pulsing some higher frequency charge to try to soften any sulphate build up. Have found a decent charge and maybe a balance charge works the best but, if its a tired battery then little can be done :y
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
If the charger is sub say 7A peek, then there is little difference, its only when its a high current charger that it needs to switch mode based on a different voltage level, basic chargers it makes no difference :y
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
If the charger is sub say 7A peek, then there is little difference, its only when its a high current charger that it needs to switch mode based on a different voltage level, basic chargers it makes no difference :y
Good to know, although I thought AGM batts could be damaged by old chargers - the transformer > rectifier > battery type?
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
Do cars with AGM batteries have different alternators? ??? :-\
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
If the charger is sub say 7A peek, then there is little difference, its only when its a high current charger that it needs to switch mode based on a different voltage level, basic chargers it makes no difference :y
Good to know, although I thought AGM batts could be damaged by old chargers - the transformer > rectifier > battery type?
No more damage than they do to a sealed standard lead acid...... ;D
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
Do cars with AGM batteries have different alternators? ??? :-\
No, well there is not a specific alternator designed for them
Modern alternators (so those in the last 10-20 years) have a data connection (usually LIN) to the PCM (Powertrain Control Module). This allows the PCM to vary the output dependent on engine load, so for example, lots of load on a cold start diesel to get it warm faster, lots of output under braking as its free energy etc etc. This helps economoy but, also allows the PCM to modify the output of a 'standard' alterntor dependent on battery chemistry
-
For better or worse, this is what I went with...
https://www.ringautomotive.com/en/product/RSC808
According to the destructions it is AGM suitable, unlike my Helfrods one which says in about 6 different places that it must not be used on AGM batteries...
From what I saw watching it yesterday, it seems to vary the voltage being fed to the battery.
-
Didn't you get a warranty from the dealer? :-\
-
For better or worse, this is what I went with...
https://www.ringautomotive.com/en/product/RSC808
According to the destructions it is AGM suitable, unlike my Helfrods one which says in about 6 different places that it must not be used on AGM batteries...
From what I saw watching it yesterday, it seems to vary the voltage being fed to the battery.
They all work the same, they start in constant current mode (so vary the voltage to maintain the constant current) to deliver the bulk charge (upto about 80% charged), then when it hits the peak battery voltage it maintains a constant voltage and the current starts to drop, this is the absorption charge. Then it goes into a float mode to keep it topped up.
Smart chargers claim more modes but, they are just sub levels of these three and they might do a better job on the float charge by turning the charger off for periods whilst monitoring the battery terminal voltage.
The major difference between AGM and standard is the peak battery voltage which is circa 100mV different, no major issue on a charger which is only putting a bit of power out.
-
Didn't you get a warranty from the dealer? :-\
Probably, but I fully expected to put a battery in it and it would be akin to asking them to top up the screen wash or replacing a failed bulb ;)
Obviously if the issue proves to be something more substantial then I will be having that conversation with them :y
-
AGMs do need an AGM compatible charger. Due to both a slight voltage difference, and due to it needing a more constant current, which older, cheaper cr battery chargers dont give.
It could be a switch/setting called AGM, or Stop/Start (as such stupidly equipped cars always use AGM)
Not entirely correct. Not all cars equipped with Stop /Start systems have AGM batteries. Many use EFB batteries which is a cheaper alternative. However AGM batteries require charging on the AGM setting, but EFB batteries can use the standard charging setting on a smart charger.
-
Showing 7.1v when I put it back on charge.
-
Showing 7.1v when I put it back on charge.
I would say that's Donald
-
I purchased one of these clicky (https://www.ebay.co.uk/itm/374141095930) a few years back ,
does quite a decent job recovering batteries that have gone low (lead acid)
it does sound like DG's battery is toast though :(
-
Well, it ended up at 11.2v today :D
Looks like 11.2/4v is its limit, which suggests that it's basically done :-\
-
I purchased one of these clicky (https://www.ebay.co.uk/itm/374141095930) a few years back ,
does quite a decent job recovering batteries that have gone low (lead acid)
it does sound like DG's battery is toast though :(
Thats just a battery charger, no 'recovery' magic :y