Omega Owners Forum

Please login or register.

Login with username, password and session length
Advanced search  

News:

Please check the Forum Guidelines at the top of the Newbie section

Pages: 1 [2] 3  All   Go Down

Author Topic: coolant leak loss but cannot see where from. 2.6 Engine  (Read 6470 times)

0 Members and 1 Guest are viewing this topic.

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #15 on: 18 May 2019, 14:03:14 »
I have some UV dye ordered. Where is the best place to look to see if it is the oil cooler plate or the coolant bridge seals? As I cannot see any drips, or patches of wet on the ground under the car.

Thanks
Addy
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

Nick W

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Chatham, Kent
  • Posts: 11051
    • Ghastly 1.0l Focus
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #16 on: 18 May 2019, 14:15:45 »
Use an inspection mirror and a torch. You can get them a lot cheaper.
Logged

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #17 on: 18 May 2019, 14:25:20 »
Sorry for all the questions, would i be looking down the back of the plenum area from the top of engine, or from under the car?

Thanks
Addy
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

Entwood

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • North Wiltshire
  • Posts: 19566
  • My Old 3.2 V6 Elite (LPG)
    • Audi A6 Allroad 3.0 DTI
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #18 on: 18 May 2019, 14:27:26 »
For coolant leaks a cheaper and easier method than UV dye and torches is simply bright yellow food colouring ! Stick a decent amount in the tank and run the engine .. the  bright yellow is easily seen with the naked eye, and it tends to dry to a solid "streak" enabling leaks to be spotted quite easily .. also flushes out/washes off easily when the problem is solved  :)
Logged

DrAndyB

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • Neston / Cheshire
  • Posts: 993
    • 2.5 V6 CDX Manual (MFL)
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #19 on: 18 May 2019, 14:39:15 »
I had a lead a few years ago - was the oil cooler plate.  Used to drip at the back of the bell housing and drip off the very bottom where there are a couple of bolts. Only did it when started to cool down after 20 mins or so (assumption being some things stayed warmer for longer !)

Clean up and new gasket/seal and jobs a good en, with new Dowty washers just in case.

Hope you get it sorted.

Logged

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #20 on: 18 May 2019, 14:45:27 »
Thanks for all the help. Gives me places to start looking.  Isn't liquid food colourant derived from petroleum, a crude oil product, which also happens to be used in gasoline, diesel fuel, asphalt, and tar? So is it still ok to put say maybe 2-3 small bottles of a bright yellow in the coolant system? As said I do have the UV dye on its way, but am happy to throw some food dye in aswell for good measure.
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

Entwood

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • North Wiltshire
  • Posts: 19566
  • My Old 3.2 V6 Elite (LPG)
    • Audi A6 Allroad 3.0 DTI
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #21 on: 18 May 2019, 15:10:21 »
Logged

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #22 on: 18 May 2019, 15:12:01 »
I not getting it untill I need it but, just checking prices incase.

https://www.ebay.co.uk/itm/New-Genuine-Vauxhall-Oil-Cooler-Radiator-Signum-Vectra-Omega-V6-2-5-2-6-3-0-3-2/273810477027

Found the banjo bolts on Auto vaux
https://www.vauxhall-car-parts.co.uk/acatalog/VAUXHALL_OIL_COOLER_FEED_PIPE_HOLLOW_BOLT_-_90424578.html
unless someone knows cheaper.

https://www.ebay.co.uk/itm/VAUXHALL-SEAL-RING-GENUINE-NEW-11076852-/152313065973?_trksid=p2349526.m4383.l4275.c1 4 of these needed

https://www.ebay.co.uk/itm/VAUXHALL-SEAL-RING-GENUINE-NEW-90409175/162424645406?epid=2229758968&hash=item25d143671e:g:X6kAAOSw32lYwY4S 4 of these needed.

Do I need to get the following?
12992646 HOLLOW CHANNEL BOLT FOR COOLER BRIDGE
12992647 COOLER BRIDGE SEAL

Is the gasket sealent any grey make or is it a special one? Also what seals, gaskets are needed to refit the plenum, and inlet bridge?

Thanks again for the help.
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #23 on: 18 May 2019, 15:13:35 »
How many of those bottles did you use, did the gel dissolve ok?

Thanks
Addy
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

Entwood

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • North Wiltshire
  • Posts: 19566
  • My Old 3.2 V6 Elite (LPG)
    • Audi A6 Allroad 3.0 DTI
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #24 on: 18 May 2019, 15:18:03 »
Not quite a full bottle, nicked it from the wife's larder :) dissolved in a bit of hot water first, emptied the header tank, filled it, ran engine until the thermostat opened at which point my leak was instantly obvious, a tiny split in a hose, the yellow oozing out was obvious. Since used the same technique on an HBV, a leaking radiator and a leaking heater matrix (not all my cars though!) .. the heater matrix only became obvious when the passenger carpet started to show an ominous yellow stain .......   :)
Logged

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #25 on: 18 May 2019, 15:21:35 »
Thats great, will look in wifes baking cupboard. If not will blag her to get some, so I can use half of it.  Not much left in my coolant tank most days.LOL
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

Alnico Blue

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • Costa del 'Saffend
  • Posts: 472
    • 2001 2.6 CDX estate
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #26 on: 18 May 2019, 16:54:09 »
Quote from: addy on 17 May 2019, 20:14:26
roughly between 4 to 6 pints. Hot weather it needs more.

'Kin 'Ell Addy  :o :o :o   . . . thought a leak like that would be visible . :o :o :o

Also my advice NOT to start buying parts until you know what the problem is.

Dye method should see you right in locating it  . . . :y :y :y
Logged
British made Celestion Alnico Blue = best sounding guitar speaker ever, sadly now made in China

Migv6 le Frog Fan

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Webs End.
  • Posts: 12535
  • Nicole's Papa
    • 3.2 Elite. Boxster. C1.
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #27 on: 18 May 2019, 17:01:16 »
Quote from: addy on 18 May 2019, 14:03:14
I have some UV dye ordered. Where is the best place to look to see if it is the oil cooler plate or the coolant bridge seals? As I cannot see any drips, or patches of wet on the ground under the car.

Thanks
Addy

Plenum, inlet manifold and sandwich plate off to access them. Use the dye first though as it will save a lot of possibly needless aggro.
Logged
Women are like an AR35. lovely things, but nobody really understands how they work.

addy

  • Senior Member
  • ****
  • Offline Offline
  • Gender: Male
  • County Durham.  UK
  • Posts: 691
    • 2.6 CD Saloon 2ltr omega
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #28 on: 18 May 2019, 22:55:56 »
Alnico Blue, I know it is alot, I am assuming due to no signs of any coolant on the floor that it is just evapourating on something hot?

I am not buying anything until I hopefully can find the problem, just looking at price of stuff.
Logged
Drives 1995 2.0ltr CD Estate.  2002 2.6 CD saloon

terry paget

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Male
  • Midsomer Norton Somerset
  • Posts: 4633
    • 3 Astras 2 Vectra
    • View Profile
Re: coolant leak loss but cannot see where from. 2.6 Engine
« Reply #29 on: 19 May 2019, 08:02:13 »
Quote from: addy on 18 May 2019, 14:25:20
Sorry for all the questions, would i be looking down the back of the plenum area from the top of engine, or from under the car?

Thanks
Addy
If it's a leaking HBV, look under the car. I have had several fail, and got a drip every 2 or 3 seconds. It only leaks when system is hot and pressurised, and in the leaky setting (MAX or MIN). If set in AUTO it will leak irregularly.
Logged
Pages: 1 [2] 3  All   Go Up
« previous next »
 

Page created in 0.016 seconds with 17 queries.