Omega Owners Forum

Please login or register.

Login with username, password and session length
Advanced search  

News:

Search the maintenance guides for answers to 99.999% of Omega questions

Pages: [1]   Go Down

Author Topic: Automatic gearbox misbehaving  (Read 2957 times)

0 Members and 1 Guest are viewing this topic.

Jan Suhr

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • Nyköping, Sweden
  • Posts: 420
    • 2 Omega Caravans 3.2 V6
    • View Profile
Automatic gearbox misbehaving
« on: 29 September 2020, 15:32:15 »
On my Winter Omega that I'm about to take out now on October 1st I did an oil change in the Auto gearbox.

Oil didn't look bad and smelled as good as it can. Changed the filter too.

Now when I drive the car it behaves strangely. When standing still and I start the gear box free wheeling a few seconds and then hook up. In worst cases with a big tugg and muffled clonk sound. It didn't do this before the oil change. Oil level is OK.

I have used Valvoline ATF Dexron III.

I haven't driven it for a long run yet, just a few laps around the block. Engine is up to temperature. When it starts running it shifts OK and kick-down works.

If I put it in 1st gear it works as expected. The free wheeling is only in Drive.


What could have happened???


Thanks

Logged
Jan Suhr
Stockholm, Sweden
www.protouring.se

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #1 on: 29 September 2020, 15:53:39 »
Level checked with engine running?
Logged
Grumpy old man

Jan Suhr

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • Nyköping, Sweden
  • Posts: 420
    • 2 Omega Caravans 3.2 V6
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #2 on: 29 September 2020, 15:58:52 »
No, no engine running.
Does that make a big difference?

Haven't done that before when I have changed auto gear oil.

Car is a 2.6 with AR25 gear box

I just drove a bit more and it is like it goes in to Neutral when you stop. Then after a few seconds it goes in to drive again and everything is OK.

Logged
Jan Suhr
Stockholm, Sweden
www.protouring.se

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #3 on: 29 September 2020, 17:01:48 »
Yes, needs to be running. If filled with engine stopped, it will be massively underfilled, and put extreme wear on the gearbox.

With engine running, ATF is pumped around torque converter and rest of system, not all drained back to sump. So with engine not running, and ATF that would be higher that the fill hole is now missing, and thats a fair amount.
Logged
Grumpy old man

amba

  • Omega Baron
  • *****
  • Offline Offline
  • Gender: Male
  • Medway towns
  • Posts: 4827
    • German V6
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #4 on: 29 September 2020, 17:06:07 »
Almost a ltr difference as I found out  :o

Run engine with all wheels off the ground and go through the gears.Back to park and add more with engine running until it starts to dribble out filler hole.Plug back in and take car for few mile drive going through the gears.Back and up in air again with engine running and do a final check and see if you can get anymore in ..again once starts to dribble out plug back in ...lower car and you should be done...and will work properly .
Logged

Nick W

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Chatham, Kent
  • Posts: 11051
    • Ghastly 1.0l Focus
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #5 on: 29 September 2020, 17:12:10 »
Quote from: TheBoy on 29 September 2020, 17:01:48
Yes, needs to be running. If filled with engine stopped, it will be massively underfilled, and put extreme wear on the gearbox.

With engine running, ATF is pumped around torque converter and rest of system, not all drained back to sump. So with engine not running, and ATF that would be higher that the fill hole is now missing, and thats a fair amount.


I've never seen an auto trans that was checked with the engine off. The Omega not having a gearbox dipstick is one of the stupid design decisions.
Logged

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #6 on: 29 September 2020, 17:25:16 »
my method is to jack up the side with the filler quite high, get as much as you can in.

Start car, lower car to level, letting excess drain out.  Drive, repeat.
Logged
Grumpy old man

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #7 on: 29 September 2020, 17:26:02 »
Quote from: Nick W on 29 September 2020, 17:12:10
Quote from: TheBoy on 29 September 2020, 17:01:48
Yes, needs to be running. If filled with engine stopped, it will be massively underfilled, and put extreme wear on the gearbox.

With engine running, ATF is pumped around torque converter and rest of system, not all drained back to sump. So with engine not running, and ATF that would be higher that the fill hole is now missing, and thats a fair amount.


I've never seen an auto trans that was checked with the engine off. The Omega not having a gearbox dipstick is one of the stupid design decisions.
I wont ask what you think of modern cars with no engine dipstick ;D
Logged
Grumpy old man

Doctor Gollum

  • Get A Life!!
  • *****
  • Offline Offline
  • Gender: Male
  • In a colds and darks puddleses
  • Posts: 29868
  • If you can't eat them, join them...
    • Feetses.
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #8 on: 29 September 2020, 20:20:45 »
The Barge has the tube, but no dipstick for the trans, and both for the engine along with the means to check it on the dash  :D
Logged
Onanists always think outside the box.

Nick W

  • Omega Queen
  • *****
  • Offline Offline
  • Gender: Male
  • Chatham, Kent
  • Posts: 11051
    • Ghastly 1.0l Focus
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #9 on: 29 September 2020, 20:25:12 »
Quote from: Doctor Gollum on 29 September 2020, 20:20:45
The Barge has the tube, but no dipstick for the trans, and both for the engine along with the means to check it on the dash  :D


Which is even more retarded than deleting the dipstick altogether.
Mercedes list the dipstick itself as a service tool.
Logged

Doctor Gollum

  • Get A Life!!
  • *****
  • Offline Offline
  • Gender: Male
  • In a colds and darks puddleses
  • Posts: 29868
  • If you can't eat them, join them...
    • Feetses.
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #10 on: 30 September 2020, 17:07:11 »
Quote from: Nick W on 29 September 2020, 20:25:12
Quote from: Doctor Gollum on 29 September 2020, 20:20:45
The Barge has the tube, but no dipstick for the trans, and both for the engine along with the means to check it on the dash  :D


Which is even more retarded than deleting the dipstick altogether.
Mercedes list the dipstick itself as a service tool.
Sealed for life and all that :D
Logged
Onanists always think outside the box.

Jan Suhr

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • Nyköping, Sweden
  • Posts: 420
    • 2 Omega Caravans 3.2 V6
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #11 on: 30 September 2020, 17:13:13 »
REPORT,

I could fill a bit over 2 litres before it started to drip out of the hole.

Now it behaves as normal.

I think it was five years since I did an auto oil change, had forgot about the running engine part  :'(

Thanks for the support guys!!
Logged
Jan Suhr
Stockholm, Sweden
www.protouring.se

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #12 on: 30 September 2020, 18:20:38 »
Wonderful news, glad its all sorted :y
Logged
Grumpy old man

Hillper

  • Intermediate Member
  • ***
  • Offline Offline
  • Gender: Male
  • Aylesbury
  • Posts: 440
  • Werthers. Winter, too hard.  Summer, too soft.
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #13 on: 06 October 2020, 17:58:24 »
Excellent result.  Well done guys.
Logged
Mods.  'Hillper boot release'.  Dimming mirror.  Cruise control. Rear parking sensors.  Becker/Rockford Fosgate/Infinity/Alpine audio.

TheBoy

  • Administrator
  • *****
  • Offline Offline
  • Gender: Male
  • Brackley, Northants
  • Posts: 106934
  • I Like Lockdown
    • Whatever Starts
    • View Profile
Re: Automatic gearbox misbehaving
« Reply #14 on: 06 October 2020, 18:20:59 »
Quote from: Hillper on 06 October 2020, 17:58:24
Excellent result.  Well done guys.
There's a blast from the past. Good to see your posts again :)
Logged
Grumpy old man
Pages: [1]   Go Up
« previous next »
 

Page created in 0.019 seconds with 17 queries.