And i think as ive got water coming in on the door sill from somewhere, as cloths in the drivers door left overnight when raining in the bottom side pocket they are always wet.So that could be the drivers door liner inside the door so ive been told.maybe its the drivers side door light inside.Will check
I had a very similar issue last year, where I thought water was gaining access over the drivers sill onto the carpet. I found a problem with the front roof gutter trim. It is designed to allow water to run behind it and exit at the lower front edge, run down the A pillar and away; however the seal between the trim and the body was excessively crushed allowing water to escape above the door and run round the seal to the bottom of the door and onto the sill. I fitted a new seal strip and changed the door seal, and although it improved matters, water was still getting onto the drivers carpet. After further advice on here, I removed the headlining, and found the offside sunroof drain connector clip to the drain pipe had broken and pipe had come off. Rainwater from the sunroof drain was dripping onto the headlining, running forwards to its lowest point, down the inside of the A pillar trim, behind the kick panel trim and into the foam insulation under the carpet. Some was also running onto, and round the door seal.
This may not be linked to your problem - but certain worth checking. As you know, the point of ingress is usually somewhere away from where it exits and shows itself in the car....