Omega Owners Forum

Please login or register.

Login with username, password and session length
Advanced search  

News:

Welcome to OOF

Pages: [1] 2  All   Go Down

Author Topic: Suspect head gaskets?  (Read 3427 times)

0 Members and 1 Guest are viewing this topic.

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Suspect head gaskets?
« on: 18 August 2009, 15:39:15 »
2.5 V6, when on M25 white smoke from exhaust when throttle pressed, got home with a misfire and temperasture spiked but not too high.

loads of mayo under oil cap BUT sniff test proves negative!! unless i been sold blue water, lol

oh and bubbles from expansion bottle too but sniff test liquid stays blue!!!!!

What do we think? im gonna strip it tomorrow as it needed for the weekend.....

your thoughts?
Logged

tunnie

  • Get A Life!!
  • *****
  • Offline Offline
  • Gender: Male
  • Surrey
  • Posts: 37588
    • Zafira Tourer & BMW 435i
    • View Profile
Re: Suspect head gaskets?
« Reply #1 on: 18 August 2009, 15:49:28 »
does it missfire from cold, but then clear?
Logged

feeutfo

  • Guest
Re: Suspect head gaskets?
« Reply #2 on: 18 August 2009, 17:44:27 »
any water in the oil? Check dip stick for white deposits/mayo.
Logged

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Re: Suspect head gaskets?
« Reply #3 on: 18 August 2009, 19:56:31 »
Hi again, i dont know as of yet if it misfires from cold, the fault occured at motorway speed and i limped home, i have just checked oil on dip stick and it looks just fine even though theres mayo on underside of oil cap!!
I tried a bars seals to cure leaking rad a few weeks ago but to no avail and replaced the rad on Saturday, i did notice a lot of what looked like melted chocolate particles in the coolant and assumed it the remnants of bars seal and flusked it out before adding fresh anti freeze BUT i may well be oil from defective oil cooler?? would a defective oil cooler let moisture into the breather system for it to be burned and come from exhaust as steam? if so im guessing this would also cause a mis fire too.... hmmm!! maybe il start with oil cooler?
« Last Edit: 18 August 2009, 19:57:16 by mark3 »
Logged

feeutfo

  • Guest
Re: Suspect head gaskets?
« Reply #4 on: 18 August 2009, 21:42:54 »
oil in coolent  def oil cooler related.
High temp could be either hg or cooler.
White smoke could be hg or alot of short journeys combined with the high temp....maybe?
Clean oil would suggest hg ok imho.

See what others say....
Logged

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Re: Suspect head gaskets?
« Reply #5 on: 18 August 2009, 21:55:58 »
It happened 10 miles from the end of a 240 mile trip, and the journeys have been nothing but long for ages! average 100 miles!!

an oil cooler letting oil into water and vice versa i can understand but would it cause white smoke from exhaust when throttle pressed?? if bad enough for water to go into crank breather system and then get burnt?

Im hoping its oil cooler off course but i suspect other wise... its my luck! will see what tomorrow brings....
Logged

sassanach

  • Omega Knight
  • *****
  • Offline Offline
  • Gender: Male
  • trowbridge
  • Posts: 1161
    • View Profile
Re: Suspect head gaskets?
« Reply #6 on: 18 August 2009, 23:52:08 »
as far as im concerned you are overdue for a headgasket job from 100,000+ anyway despite what you hear on here about the rarity of failures
Logged

JamesV6CDX

  • Omega Queen
  • *****
  • Offline Offline
  • Gloucestershire/Buckinghamshire
  • Posts: 16640
    • Omega 3.2 Retail MV6 LPG
    • View Profile
Re: Suspect head gaskets?
« Reply #7 on: 19 August 2009, 00:21:42 »
Quote
as far as im concerned you are overdue for a headgasket job from 100,000+ anyway despite what you hear on here about the rarity of failures

In my personal experience, I'd have to agree - (especially on 3.0 models 1998 +)  ::)
Logged

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Re: Suspect head gaskets?
« Reply #8 on: 20 August 2009, 08:43:55 »
Yesterdays stripping was delayed by work, so todays the day for a good strip down, wish me luck, wish me oil cooler, lol
Logged

Kevin Wood

  • Global Moderator
  • *****
  • Offline Offline
  • Gender: Male
  • Alton, Hampshire
  • Posts: 36427
    • Jaguar XE 25t, Westfield
    • View Profile
Re: Suspect head gaskets?
« Reply #9 on: 20 August 2009, 09:38:19 »
If you're getting steady bubbling from the header tank that's not due to boiling or trapped air then it does point to HG. Ditto white smoke from the exhaust.

Each fire ring on these engines is surrounded by water jacket so the head gasket can only blow into the water hence oil normally stays clear.

Exhaust fumes blown into the water jacket can contaminate the coolant with a sludgy brown substance IME. Might pay to do the oil cooler, or at least inspect it very carefully while you're there though.

Kevin
Logged
Tech2 services currently available. See TheBoy's price list: http://theboy.omegaowners.com/

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Re: Suspect head gaskets?
« Reply #10 on: 20 August 2009, 13:11:17 »
Oh joy!!!!! ...............NOT, lol



Off with its heads! havent i read that somewhere before just recently? lol
Logged

ScottieMV6

  • Omega Knight
  • *****
  • Offline Offline
  • Gender: Male
  • Swinton, Manchester
  • Posts: 1140
    • View Profile
Re: Suspect head gaskets?
« Reply #11 on: 20 August 2009, 14:17:01 »
Yes that would be me!

Done just over 100K and head gaskes weren't pretty!

Good luck (sure you won't need it being a mechanic)! :y
Logged
I'd rather be scared to death than bored to death!!

mark3

  • Junior Member
  • **
  • Offline Offline
  • Gender: Male
  • Rainahm Village~Essex
  • Posts: 143
    • View Profile
Re: Suspect head gaskets?
« Reply #12 on: 20 August 2009, 22:23:56 »
What a **** of a job! oh my god it was horrid but hopefully refitting will be better, it usually is..



One cam from each head had to come out to get to head bolts!




Its defo head gasket on two cylinders of this head!




There both off, 7 hours! bloody horrid job!


But my god the crap i have removed to get to this point?






Toyota Supra 7MGTE head gaskets are positively simple to do after these!!!
Logged

Kevin Wood

  • Global Moderator
  • *****
  • Offline Offline
  • Gender: Male
  • Alton, Hampshire
  • Posts: 36427
    • Jaguar XE 25t, Westfield
    • View Profile
Re: Suspect head gaskets?
« Reply #13 on: 21 August 2009, 09:27:40 »
Might be worth removing and re-sealing the oil cooler and thermostat while you're there. Looks like something has been making a mess down in the middle of the vee.

Glad the diagnosis was correct.

Kevin
Logged
Tech2 services currently available. See TheBoy's price list: http://theboy.omegaowners.com/

Wayne

  • Guest
Re: Suspect head gaskets?
« Reply #14 on: 22 August 2009, 00:08:06 »
Oh jesus, hope mine aint like that! 

where can i get that "do it yourself" test kit to test my coolant tank to see if it changes colour, indicating my head gaskets gone?
« Last Edit: 22 August 2009, 00:08:34 by Wayne »
Logged
Pages: [1] 2  All   Go Up
« previous next »
 

Page created in 0.011 seconds with 17 queries.